Warranty Assist

Only components approved by the manufacturer can be covered.
Any component not specifically listed below will not be covered.

Electrics
Alternator, electric window motors, engine cooling fan motors, horn,
indicator flasher relay, starter motor and sunroof motor / hydraulics.

Electronic control units (ECUs) & computers 
The engine management ECU and any other computers that directly
control your vehicle’s alarm and immobilisation functions, that were
originally fitted to your vehicle when it was first manufactured are
covered (upgraded or revised software and firmware, including
software and firmware patches and updates, relating directly or
indirectly to any components of your vehicle and any retro-fitted
ECUs & computers are not covered.)

Braking system
Anti-lock braking system (ABS) pump & control unit, calipers, master
& wheel cylinders, pressure reducing & proportioning valves, and
vacuum servo.

Casings
Casings are covered provided they have been damaged as a direct
result of the failure of a covered Component.

Clutch
Clutch cable, master & slave hydraulic cylinders and pedal assembly.

 Cooling systems
Engine cooling water radiator, heater radiator, thermostat & housing,
viscous cooling fan couplings and water pump.

Engine
All internally lubricated parts are covered including:
Camshafts & bearings, camshaft followers & rockers (including
hydraulic lash adjusters), connecting rods & bearings, crankshaft
& bearings, cylinder block, cylinder bores & liners & seals, cylinder
heads, internal bushings & bearings, oil pump & drive, pistons &
rings, timing gears, chain, tensioner, valves, springs & guides (burnt
or pitted valves and valve seats are not covered). 

The following engine parts are also covered:
Crankshaft pulley and cylinder head gasket.
Camshaft drive belts are covered as follows:
Camshaft drive belts and tensioners (subject to documented
proof that the last due change of camshaft drive belt has taken
place as specified by the manufacturer’s recommended servicing
schedule).

Flywheels & drive plates
Flexible drive plate for the automatic transmission’s torque
converter, solid & dual mass flywheels (flywheels damaged by
clutch friction plates are not covered) and starter ring gear.

Fuel system
Air flow sensors and meters, fuel gauge sender unit, fuel pressure
regulators & accumulators, fuel pumps (including pre-pumps,
low, high pressure pumps & injection pumps), injectors (including
petrol, diesel & single-point injectors.

Gearboxes
(Including automated manual gearboxes, automatic gearboxes, four
wheel drive transfer gearboxes, hybrid transaxles, manual gearboxes
and transaxles.)
Automatic transmission brake bands & clutches & modulator valves, drive chains, gear lever, gears, hydraulic gear-shift
governors & internal servos & valve blocks, internal bearings &
bushes, oil pumps, selector forks, shafts (all, including extension
shafts), synchromesh hubs and rings and torque converter.

Ignition system
Camshaft sensors, crankshaft sensors and ignition coils.

Oil Seals and Gaskets
The engine crankshaft rear oil seal and the main gearbox input
shaft oil seal are both covered and other oil seals and gaskets that
would necessitate the removal of the engine, a gearbox or a final
drive unit to carry out repairs are all covered subject to any oil
leak from them being sufficiently advanced that oil can be seen to
be dripping (slight leaks causing only oil misting or staining are not
covered).

Steering
Column shaft & tilt mechanism & couplings, hydraulic pumps &
reservoir & pressure pipes, steering & idler boxes, rack and pinion
assembly (including hydraulic rams and electric motors) and track
rods & track rod ends.

Suspension
Wheel bearings.
 
Transmissions
(including front & centre & rear differentials, front & rear live axles
and drive shafts.)
Constant velocity joints, crown wheels & pinions, differential
gears & thrust washers, external drive shafts, internal bushes
& bearings (including wheel bearings) & shafts, internal parts of
differential locking mechanisms, propeller shafts & propeller shaft
couplings & centre bearings and universal joints.

Turbocharger
Turbocharger units.